Sportwagon frame

Discussion in 'Drag'n Wagons' started by sportwagon68, Sep 27, 2019.

  1. sportwagon68

    sportwagon68 Active Member

    Im looking for some guidance. My 68 sportwagon has some significant rust in the front of the frame. Are there any other frames that would fit or interchange? Newer estate wagons? Any help would be much appreciated! Greg
     

    Attached Files:

    Last edited: Sep 27, 2019
  2. Donuts & Peelouts

    Donuts & Peelouts Life's 2 Short. Live like it.

    Would you want one from CA
     
  3. sportwagon68

    sportwagon68 Active Member

    Not sure if that's cost effective with shipping but I'm listening.
     
  4. Doo Wop

    Doo Wop Where were you in '62?

    All you need are front frame horns?
     
    sportwagon68 likes this.
  5. sportwagon68

    sportwagon68 Active Member

    Yes, the rest looks pretty good from the drivers door back
     
  6. Duane

    Duane Member

    The side frame rail behind the front frame horns looks pretty bad to me.

    A Sport wagon is an A-body so a big car frame, like one from an Estate wagon would not help.

    What you would need would be a frame from either a 68-72 A-Body wagon, or one from a 68-72 El Camino.

    The El Camino frames are boxed. I am not sure if the Sport wagon frames are but either would work. Both would give you the longer wheel base and the different frame section at the rear.

    If your car does not have a boxed frame and you end up using one, then you will need to change the trans cross member to the convertible style, that are shorter.

    You could also use a 4-door frame and cut off/weld the rear section of your frame to it if it is ok. That would give you another option if you could not find the right frame for your car.
    Duane
     
    Donuts & Peelouts likes this.
  7. Gallagher

    Gallagher Founders Club Member

  8. sportwagon68

    sportwagon68 Active Member

  9. sportwagon68

    sportwagon68 Active Member

    I thought the el Camino frames were a little bit shorter? Thank you for the info!
     
  10. Duane

    Duane Member

    "I thought the el Camino frames were a little bit shorter? Thank you for the info!"

    No I don't think so,
    They have the 116" wheel base, the same front frame section, and the same rear section as the wagons. The reason they are different (from a 2 or 4-door) in the back is because of the "flat floor" back there. The rear frame on the 2 & 4-door A-bodies goes up in the back due to the trunk and gas tank filler neck.

    You need to check your Sport wagon and make sure your wheel base is 116".

    I definitely would not want to repair your frame. If it is that bad in the front, and is boxed like I think it is, then all kinds of stuff gets stuck in the frame rails and unless you get it out, it will retain moisture and rust. I had a convertible frame rot out in the same place as what you are showing and replaced the entire frame. When I cut the side rail reinforcement sections off, the original side rails were almost at the point of looking like Swiss cheese, due to the amount of dirt that had packed up in them.


    If you go to the "How to build an X-Camino" thread and look on page 2, you will see the Frame I put together for my car, which is basically an El Camino frame. That should look like your frame in the back.
    Duane
     
    Last edited: Sep 27, 2019
    sportwagon68 likes this.
  11. sportwagon68

    sportwagon68 Active Member

    Awesome, thank you. I will read up on that!
     
  12. sportwagon68

    sportwagon68 Active Member

    im looking at the chassis manual and it says the "sportwagon" is 121 inches and other wagons are "116". I measured mine just to confirm, and it is 121". It is boxed and I agree, im sure there is much more hiding than I am aware of..
     

Share This Page